水平圆管内油水两相分散混合液的流动特征
Investigation on the characteristics of oil-water two-phase dispersed flow in horizontal pipes
查看参考文献16篇
|
文摘
|
管道内油水两相分散流动中的压降受相含率、相分布和流速等参数的影响,研究表明同一混合液流速条件下,随体积含油率的增大,压降呈现为先增加后减小的趋势,在连续相的相转化点处压降达到峰值。该文结合均相流模型和非牛顿流体流动理论,对管道内油水两相流动的压降进行分析,结果显示已有混合液表观黏度预测模型计算得到的压降与实验值存在较大偏差。综合考虑管道流动中油水两相的相分布特征,优化得到了油水分散混合液表观黏度的预测模型,可应用于计算流动中的压降,且精度均在10%以内,为管道混输系统的设计,以及两相分散流动理论的发展提供可靠的理论依据。 |
|
其他语种文摘
|
The pressure gradient of oil-water two-phase dispersed flow in pipe is affected by series of parameters included phase holdup,phase distribution and flow rate.The pressure gradient increases as the increasing of oil volume fraction firstly and decreases after the peak where the phase inversion happened.The prediction of pressure gradient was researched by combining the homogeneous flow model and the non-Newtonian fluid flow theory in this work.It is poor to calculate the pressure gradient by the existed apparent viscosity prediction models.And a series of new apparent viscosity prediction models was introduced which considers the characteristics of dispersed phase distribution.In conclusion,the given apparent viscosity prediction model can be used to calculate the pressure gradient of oil-water dispersed flow,which is with the accuracy of 10%.It is important to the design of the pipeline transportation system and the development of two-phase dispersed flow theory. |
|
来源
|
水动力学研究与进展. A辑
,2019,34(6):788-794 【核心库】
|
|
DOI
|
10.16076/j.cnki.cjhd.2019.06.012
|
|
关键词
|
油水混合液
;
表观黏度
;
管道流动
;
压降预测
|
|
地址
|
1.
中海石油(中国)有限公司深圳分公司, 深圳, 518067
2.
中国科学院力学研究所, 北京, 100190
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
1000-4874 |
|
学科
|
力学 |
|
基金
|
国家自然科学基金
|
|
文献收藏号
|
CSCD:6645449
|
参考文献 共
16
共1页
|
|
1.
Yang L. Gas-liquid flow splitting in T-junction with inclined lateral arm.
Journal of Hydrodynamics,2018,30(1):173-176
|
被引
1
次
|
|
|
|
|
2.
Li D H. Measurement of oil-water flow via the correlation of turbine flow meter, gamma ray densitometry and drift-flux model.
Journal of Hydrodynamics,2015,27(4):548-555
|
被引
3
次
|
|
|
|
|
3.
Guo J X. Heavy oilwater flow patterns in a small diameter vertical pipe under high temperature/pressureconditions.
Journal of Petroleum Science & Engineering,2018,171:1350-1365
|
被引
1
次
|
|
|
|
|
4.
Abubakar A. Effect of pipe inclination on holdups/velocity ratios of oil-water flow without and with addition of drag reducing polymer.
International Journal of Multiphase flow,2017,89:359-374
|
被引
1
次
|
|
|
|
|
5.
Piroozian A. An experimental study of flow patterns pertinent to waxy crude oil-water two-phase flows.
Chemical Engineering Science,2017,164(8):313-332
|
被引
4
次
|
|
|
|
|
6.
陈小平. 稠油动力黏度预测研究.
水动力学研究与进展(A辑),2017,32(1):11-18
|
被引
1
次
|
|
|
|
|
7.
张栋. 超稠原油的流变学特性及流动特征研究.
水动力学研究与进展(A辑),2016,31(2):145-150
|
被引
2
次
|
|
|
|
|
8.
朱克勤. 非牛顿流体力学研究的若干进展.
力学与实践,2006,28(4):1-8
|
被引
10
次
|
|
|
|
|
9.
Cengel J A. La-minar and turbulent flow of unstable liquid-liquid emulsions.
AIChE Journal,1962,8(3):335-339
|
被引
2
次
|
|
|
|
|
10.
Pal R. Viscosity concentration relationships for emulsions.
Journal of Rheology,1989,33(5/8):1021-1045
|
被引
9
次
|
|
|
|
|
11.
Lovick J. Experimental studies on the dual continuous flow pattern in oil-water flows.
International Journal of Multiphase Flow,2004,30:139-157
|
被引
18
次
|
|
|
|
|
12.
Ngan K H. A methodology for predicting phase inversion during liquid-liquid dispersed pipeline flow.
Chemical Engineering Research and Design,2009,87(3):318-324
|
被引
1
次
|
|
|
|
|
13.
Zhang J. Apparent viscosity of oil-water (coarse) emulsion and its rheological characterization during the phase inversion region.
Journal of Dispersion Science and Technology,2013,34(8):1148-1160
|
被引
1
次
|
|
|
|
|
14.
Brinkman H C. The viscosity of concentrated suspensions and solutions.
Journal of Chemical Physics,1952,20(4):571
|
被引
80
次
|
|
|
|
|
15.
Pal R. Novel viscosity equations for emulsions of two immiscible liquids.
Journal of Rheology,2001,45(2):509-520
|
被引
3
次
|
|
|
|
|
16.
吴奇霖. 粗油水乳状液的流变特性.
油气储运,2014,33(5):531-537
|
被引
2
次
|
|
|
|
|
了解气象卫星更多信息，请访问