基于高分辨率谱估计的早期转子断条故障诊断
High-resolution spectral analysis for incipient broken rotor bar diagnosis
查看参考文献16篇
文摘
|
以快速傅里叶变换(FFT)为基础的电机电流信号特征分析(MCSA)具有频率分辨率低的固有缺陷,从而严重影响了鼠笼电机早期转子断条故障的诊断性能。为解决这一问题,提出基于高分辨率谱估计的早期转子断条故障诊断方法。首先利用Hilbert变换和离散小波变换对单相定子电流信号预处理,然后采用扩展Prony算法对预处理后的信号进行定性/定量分析。运用该方法对不同故障严重程度、不同负载条件下的3 kW电机稳态定子电流信号进行分析,并与FFT分析结果做对比。实验结果表明,即使在短时数据条件下所提方法仍然能够准确诊断出早期转子断条故障,验证了该方法的有效性和优越性。 |
其他语种文摘
|
Motor current signal analysis (MCSA) based on fast Fourier transform (FFT) has its inherent drawback such as low resolution in frequency domain,thus,the detection performance becomes inaccurate for incipient broken rotor bar in squirrel-cage induction motor. In this paper,a high-resolution spectral analysis method is proposed to solve this issue. Firstly,data pre-processing for single phase stator current is achieved by Hilbert transform and discrete wavelet transform (DWT). Then,extended Prony algorithm is utilized for pre-processed signal qualitative and quantitative analysis. The steady-state stator current of 3kw squirrel-cage induction motor can be analyzed under different fault degrees and different operating conditions. The comparison is conducted with FFT. The experimental results shows the effectiveness and superiority on incipient broken rotor bar fault diagnosis even for short-time data sequence. |
来源
|
仪器仪表学报
,2017,38(2):279-287 【核心库】
|
关键词
|
鼠笼电机
;
Hilbert变换
;
小波变换
;
扩展Prony算法
;
故障诊断
|
地址
|
1.
沈阳工业大学信息科学与工程学院, 沈阳, 110870
2.
辽宁科技大学电子与信息工程学院, 鞍山, 114051
3.
中国科学院沈阳自动化研究所, 沈阳, 110016
|
语种
|
中文 |
文献类型
|
研究性论文 |
ISSN
|
0254-3087 |
学科
|
机械、仪表工业 |
基金
|
中国科学院重点部署项目
;
辽宁省科技计划项目
|
文献收藏号
|
CSCD:5939115
|
参考文献 共
16
共1页
|
1.
裴大茗. 船舶PHM技术综述.
电子测量与仪器学报,2016,30(9):1289-1297
|
被引
15
次
|
|
|
|
2.
Shin S M. Motor health monitoring at standstill through impedance analysis.
IEEE Transactions on Industrial Electronics,2016,63(7):4422-4431
|
被引
2
次
|
|
|
|
3.
江星星. 多共振频带自适应检测的轴承微弱故障诊断方法.
电子测量与仪器学报,2016,30(4):526-533
|
被引
7
次
|
|
|
|
4.
孙春雨. 基于正交匹配与周期能量的滚动轴承故障诊断.
电子测量与仪器学报,2016,30(3):423-430
|
被引
1
次
|
|
|
|
5.
Eren L. Motor current signature analysis via four-channel FIR filter banks.
Measurement,2016,8(9):322-327
|
被引
1
次
|
|
|
|
6.
贾朱植. 鼠笼电机转子断条故障的定子电流信号平方解调分析诊断方法.
仪器仪表学报,2015,36(9):2097-2103
|
被引
4
次
|
|
|
|
7.
Sahraoui M. The use of the modified prony 's method for rotor speed estimation in squirrel-cage induction motors.
IEEE Transactions on Industry Applications,2016,52(3):2194-2202
|
被引
1
次
|
|
|
|
8.
Culbert I M. Using current signature analysis technology to reliably detect cage winding defects in squirrel-cage induction motors.
IEEE Transactions on Industry Applications,2007,43(2):422-428
|
被引
1
次
|
|
|
|
9.
祝洪宇. 基于变频器供电侧电流Hilbert 解调制方法的空载电机转子断条故障诊断.
仪器仪表学报,2014,35(1):140-147
|
被引
5
次
|
|
|
|
10.
Ayhan B. On the use of a lower sampling rate for broken rotor bar detection with DTFT and AR-based spectrum methods.
IEEE Transactions on Industrial Electronics,2008,55(3):1421-1434
|
被引
3
次
|
|
|
|
11.
Kim Y H. Highresolution parameter estimation method to identify broken rotor bar faults in induction motors.
IEEE Transactions on Industrial Electronics,2013,60(9):4103-4117
|
被引
5
次
|
|
|
|
12.
Lee J S. Bearing fault detection of IPMSMs using zoom FFT.
Journal of Electrical Engineering & Technology,2016,11(5):1235-1241
|
被引
3
次
|
|
|
|
13.
贾朱植. 时变转速运行状态下鼠笼电机转子断条故障诊断.
仪器仪表学报,2016,37(7):834-842
|
被引
2
次
|
|
|
|
14.
Hwang D H. Robust diagnosis algorithm for identifying broken rotor bar faults in induction motors.
Journal of Electrical Engineering & Technology,2014,9(1):37-44
|
被引
2
次
|
|
|
|
15.
Marple S L.
Digital spectral analysis:With applications,1987
|
被引
2
次
|
|
|
|
16.
Mallat S G. A theory for multiresolution signal decomposition:The wavelet representation.
IEEE Transactions on Pattern Analysis and Machine Intelligence,1989,11(7):674-693
|
被引
1774
次
|
|
|
|
|