帮助 关于我们

返回检索结果

发射光谱诊断电弧加热器漏水故障的试验研究
Experimental study on leak detection of cooling water in arc heater based on emission spectroscopy

查看参考文献19篇

林鑫 1   陈连忠 1   董永晖 1   欧东斌 1 *   李飞 2   余西龙 2  
文摘 电弧加热器是飞行器热防护系统地面考核试验的首选设备。电弧加热器在运行时,由于其电极工作在高温环境,普遍采用高压水进行冷却,试验中存在着由于电极烧穿漏水导致加热器严重烧损的风险。由于高温气流的恶劣环境,目前尚无有效监测手段。本文作者建立一套以氢原子Hα( 656. 28nm)和氧原子( 777. 19nm)发射谱线作为目标谱线的发射光谱监测系统,通过分析电弧加热器故障条件和正常运行下高温流场中的发射光谱特性,诊断某高焓电弧加热器因烧蚀出现的电极漏水故障,并在考虑温度误差的前提下对该光谱测量系统测量灵敏度进行评估,获得了A、B 两种试验状态下的漏水探测极限: A 状态下约为1. 85 ~ 0. 94g /s; B 状态下,2. 12 ~ 0. 98g /s。试验结果表明,发射光谱应用于电弧加热器漏水故障诊断是切实可行的。
其他语种文摘 High-enthalpy arc heaters play an important role in the development of thermal protection materials and heat shield structures for entry vehicles because they are capable of producing longtime and representative flow environments. Owing to the large heat flux loading on the electrode,the erosion of the electrode is inevitable. Generally,high pressure water is used for cooling of the electrode. The arc heater may suffer serious damage caused by electrode leak,especially for hundreds or even thousands of seconds aerodynamic heating tests. Therefore,it is necessary to develop fast response diagnostic technique to monitor the operating status of the facility and determine the initial time of water leakage to avoid costly arc-heater failure. Because of the extreme conditions inside the arc-heater section, options for measurements of the test gases are limited,and optical spectroscopy-based measurements present a diagnostic opportunity. Optical Emission Spectroscopy ( OES ) is widely used for measuring gas parameters of high-temperature flow field because it is non-intrusive,high sensitive,and just constituted of simple instruments. In our studies,the 656. 28 nm emission spectral line of the atomic hydrogen and the 777. 19 nm emission spectral line of the atomic oxygen are utilized for routinely in situ monitoring the operating status and determining the initial time of water leakage at a high-enthalpy arc heater. According to the intensity ratio of the two emission spectral lines,the mass fluxes of the water leakage can be derived,which are 1. 85 ~ 0. 94g /s and 2. 12 ~ 0. 98g /s,corresponding to equilibrium temperatures equal to 6000 ~ 8000K and 5500 ~ 7500K under two different test conditions,respectively. The current test results of this study illustrate the feasibility and potential of the OES technology in high-enthalpy arc heater safety diagnosis,especially on the water leakage diagnosis.
来源 实验流体力学 ,2016,30(4):14-19 【核心库】
DOI 10.11729/syltlx20150155
关键词 电弧加热器 ; 氢原子 ; 氧原子 ; 发射光谱 ; 漏水检测
地址

1. 中国航天空气动力技术研究院, 电弧等离子应用装备北京市重点实验室, 北京, 100074  

2. 中国科学院力学研究所, 高温气体动力学国家重点实验室, 北京, 100190

语种 中文
文献类型 研究性论文
ISSN 1672-9897
学科 航天(宇宙航行)
基金 国家自然科学基金资助项目
文献收藏号 CSCD:5792208

参考文献 共 19 共1页

1.  Grinstead J H. Flow property measurement using laser-induced fluorescence in the NASA ames interaction heating facility. AIAA-2011-1091,2011 被引 2    
2.  Splinter S C. Comparative measurements of earth and Martian entry environments in the NASA Langley HYMETS facility. AIAA-2011-1014,2011 被引 1    
3.  Park C. Comparison of enthalpy determination methods for an arc-jet facility. Journal of Thermophysics and Heat Transfer,2006,20(4):672-679 被引 3    
4.  Kim S. Development of tunable diode laser absorption sensors for a large-scale arc-heated-plasma wind tunnel,2004 被引 6    
5.  Martin M N. Monitoring temperature in high enthalpy arc-heated plasma flows using tunable diode laser absorption spectroscopy. AIAA-2013-2761,2013 被引 1    
6.  Winter P M. Radiation transport analysis of emission spectroscopic measurements in the plenum region of the NASA IHF arc jet facility. AIAA-2014-2489,2014 被引 1    
7.  Takayanagi H. Arc heated wind tunnel flow diagnostics using laser-induced fluorescence of atomic species. AIAA-2009-1449,2009 被引 1    
8.  Inman J A. Nitric oxide PLIF measurements in the Hypersonic Materials Environmental Test System(HYMETS). AIAA-2011-1090,2011 被引 1    
9.  Vancrayenes B. Emission spectroscopic survey of graphite ablation in the VKI plasmatron. AIAA-2006-2907,2006 被引 1    
10.  Yalin A P. Spatial profiles of N + 2 concentration in an atmospheric pressure nitrogen glow discharge. Plasma Sources Science and Technology,2002,11:248-253 被引 1    
11.  Lin X. Measurements of non-equilibrium and equilibrium temperature behind a strong shock wave in simulated martian atmosphere. Acta Mechanica Sinica,2012,28(5):1296-1302 被引 2    
12.  Lin X. CO concentration and temperature measurements in a shock tube for Martian mixtures by coupling OES and TDLAS. Applied Physics B:Lasers and Optics,2012,110:401-409 被引 2    
13.  Dikalyuk A S. Nonequilibrium spectral radiation behind the shock waves in Martian and Earth atmospheres. AIAA-2013-2505,2013 被引 1    
14.  Winter M W. Determination of temperature profiles in the plenum region of the NASA IHF arc jet facility from emission spectroscopic measurements. AIAA-2013-3016,2013 被引 1    
15.  Winter M W. Emission spectroscopic measurements in the plenum region of the NASA IHF arc jet facility. AIAA-2010-4522,2010 被引 1    
16.  Winter M W. Emission spectroscopic measurements with an optical probe in the NASA Ames IHF arc jet facility. AIAA-2012-1016,2012 被引 2    
17.  张志成. 高超声速气动热和热防护,2003:261-263 被引 2    
18.  Baum G M. Charts for equilibrium flow properties of air in hypervelocity nozzles. NASA TN D-1333,1962 被引 1    
19.  Laux C O. Optical dignostics and radiative emission of air plasmas,1993 被引 2    
引证文献 2

1 林鑫 基于原子发射光谱的中低焓电弧加热器漏水故障诊断 实验流体力学,2019,33(5):82-87
被引 0 次

2 林键 电弧加热高焓风洞流场诊断和驻室参数计算方法 空天技术,2023,2023(3):52-59,87
被引 0 次

显示所有2篇文献

论文科学数据集
PlumX Metrics
相关文献

 作者相关
 关键词相关
 参考文献相关

版权所有 ©2008 中国科学院文献情报中心 制作维护:中国科学院文献情报中心
地址:北京中关村北四环西路33号 邮政编码:100190 联系电话:(010)82627496 E-mail:cscd@mail.las.ac.cn 京ICP备05002861号-4 | 京公网安备11010802043238号