帮助 关于我们

返回检索结果

丙烯腈-丁二烯-苯乙烯塑料、四溴双酚A混合物的热解实验: 含溴二噁英生成研究
Experimental Investigation on the Formation of Polybrominated Dibenzo-pdioxins(PBDDs) and Dibenzofurans (PBDFs) during the Pyrolysis of Acrylonitrile- Butadiene-Styrene (ABS) and Tetrabromobisphenol A (TBBPA) Blends

查看参考文献22篇

梅俊   陈佩   彭平安 *  
文摘 模拟电子垃圾热回收处理过程,将丙烯腈-丁二烯-苯乙烯塑料(ABS)、四溴双酚A(TBBPA)分别与4种金属(Cu、Fe、Zn和Ni)进行混合,在自制的加热装置内开展了不同气氛、不同温度条件下热解实验研究。对产物溴代二噁英(PBDD/Fs)检测显示, 2,3,7,8-TBDF、2,3,7,8-TBDD及1,2,3,4,7,8-与1,2,3,6,7,8-HxBDD为主要产物,其中2,3,7,8-TBDF含量最高,约占总PBDD/Fs的12%~ 90%。反应生成的8种2,3,7,8-PBDD/Fs浓度范围为0.05~ 2 082 ng·g~(-1)。在同等实验条件下,温度升高有利于ABS塑料混合物中PBDD/Fs的生成。Cu、Fe、Zn和Ni四种金属都具有催化效应。空气、氮气气氛下热解实验显示,空气气氛下PBDD/ Fs的生成量大,2种条件下生成的二噁英总量比值在0.8~ 99.6之间变化。无金属催化条件下此比值变化范围较小,为0.8~ 1.5;在金属参与条件下,此比值变化范围加大,为1.2~ 99.6;其中,在Cu和Fe参与下,此比值较高。各种热解条件下形成的PBDD/Fs都具有PBDFs > PBDDs的特征。研究结果说明,虽然无金属参与条件下含TBBPA的ABS热解生成溴代二噁英浓度较低,但金属(如Cu等)存在时,此类污染物的浓度显著增加。
其他语种文摘 The formation of polybrominated dibenzo-p-dioxins (PBDDs) and dibenzofurans (PBDFs) during the pyrolysis of acrylonitrile-butadiene-styrene (ABS) and tetrabromobisphenol A (TBBPA) blends containing or not one of the four metals (Cu, Fe, Zn and Ni) was investigated using a self-made apparatus at different temperatures and carrier gas compositions. Results showed that 2,3,7,8-TBDF, 2,3,7,8-TBDD, 1,2,3,4,7,8-HxBDD and 1,2,3,6,7,8-HxBDD were the main products, and that the highest concentration congener was 2,3,7,8-TBDF, accounting for 12% ~ 90% of total concentration of the products. The total concentration of 2,3,7,8-PBDD/Fs ranged from 0.05 to 2 082 ng·g~(-1). Under the same conditions, high temperatures favored the formation of PBDD/Fs during the pyrolysis. The four metals were found to have a catalytic effect on the formation of PBDD/Fs. Higher concentration of PBDD/Fs was detected when air was used as carrier gas, and the ratios of ΣPBDD/Fs to the total concentration of the products under the two gas conditions (with air and N2 as carrier gas, respectively) ranged from 0.8 to 99.6. In the absence of the metals, the ratios of ΣPBDD/Fs to the total concentration of the products showed little variation (ranging from 0.8 to 1.5); while, in the presence of the metals, the ratios varied greatly from 1.2 to 99.6. Under the experimental conditions of the present study, the concentrations of PBDFs formed during the pyrolysis were much higher than those of PBDDs. The metals such as Cu could increase the formation of PBDD/Fs during the pyrolysis of ABS/TBBPA blends, although the levels of PBDD/Fs formed in the absence of the metals during the pyrolysis were relatively low.
来源 生态毒理学报 ,2016,11(2):170-178 【核心库】
DOI 10.7524/AJE.1673-5897.20150729001
关键词 溴代二噁英 ; ABS塑料 ; 四溴双酚A ; 金属 ; 热解
地址

中国科学院广州地球化学研究所, 有机地球化学国家重点实验室;;广东省环境资源利用与保护重点实验室, 广州, 510640

语种 中文
文献类型 研究性论文
ISSN 1673-5897
学科 环境科学基础理论
基金 国家自然科学基金
文献收藏号 CSCD:5766933

参考文献 共 22 共2页

1.  Ladou J. Printed circuit board industry. International Journal of Hygiene and Environmental Health,2006,209(3):211-219 被引 11    
2.  Guo J Y. Recycling of non-metallic fractions from waste printed circuit boards: A review. Journal of Hazardous Materials,2009,168(2/3):567-590 被引 17    
3.  Wang R. Recycling of non-metallic fractions from waste electrical and electronic equipment (WEEE): A review. Waste Manage,2014,34(8):1455-1469 被引 4    
4.  彭平安. 电子垃圾的污染问题. 化学进展,2009,21(2/3):550-557 被引 16    
5.  高丹丹. 不同暴露方式四溴双酚A的代谢及毒性特征. 环境与健康杂志,2015,32(2):165-168 被引 2    
6.  Lenoir D. The influence of water and metals on PBDD/F concentration in incineration of decabrombiphenyl ether in polymeric matrices. Chemosphere,1994,28(11):1921-1928 被引 3    
7.  Luijk R. The influence of the polymer matrix on the formation of polybrominated dibenzo-pdioxins (PBDDs) and polybrominated dibenzofurans (PBDFs). Chemosphere,1991,23(8/10):1173-1183 被引 1    
8.  Thies J. Tetrabromobisphenol A (TBBA), its derivatives and their flame retarded (FR) polymers- Content of polybrominated dibenzo-p-dioxins (PBDD) and dibenzofurans (PBDF)-PBDD/F formation under processing and smouldering (worst case) conditions. Chemosphere,1990,20(10/12):1921-1928 被引 3    
9.  李会茹. 大气样品中氯代和溴代二噁英/呋喃同位素稀释分析方法的建立及应用. 分析化学研究报告,2008,36(2):150-156 被引 2    
10.  肖潇. 贵屿某电子垃圾拆解点附近大气颗粒物中氯代/溴代二英、四溴双酚A污染水平研究. 环境科学学报,2012,32(5):1142-1148 被引 13    
11.  Alaee M. An overview of commercially used brominated flame retardants, their applications, their use patterns in different countries/regions and possible modes of release. Environment International,2003,29(6):683-689 被引 136    
12.  肖望东. 阻燃ABS及其耐热性研究. 工程塑料应用,2004,32(11):14-16 被引 3    
13.  He W. WEEE recovery strategies and the WEEE treatment status in China. Journal of Hazardous Materials,2006,136(3):502-512 被引 9    
14.  Ebert J. Formation of PBDD/F from flame-retarded plastic materials under thermal stress. Environment International,2003,29(6):711-716 被引 13    
15.  Bonilla J. Analyses of brominated dibenzo-p-dioxins and dibenzofurans in ABS resins containing brominated flame retardants. Journal of Fire Sciences,1990,8(6):395-404 被引 1    
16.  Luijk R. The formation of polybrominated dibenzo-p-dioxins (PBDDs) and dibenzofurans (PBDFs) during pyrolysis of polymer blends containing brominated flame retardants. Chemosphere,1992,25(3):361-374 被引 2    
17.  Wichmann H. Thermal formation of PBDD/F from tetrabromobisphenol A-A comparison of polymer linked TBBP A with its additive incorporation in thermoplastics. Chemosphere,2002,47(4):349-355 被引 8    
18.  Hutzinger O. PBDD and PBDF from brominated flame retardants: Combustion equipment, analytical methodology and synthesis of standards. Chemosphere,1989,18(1):1235-1242 被引 1    
19.  Duan H B. Characterization and inventory of PCDD/Fs and PBDD/Fs emissions from the incineration of waste printed circuit board. Environmental Science & Technology,2011,45(15):6322-6328 被引 11    
20.  Lai Y C. Inhibition of polybrominated dibenzo-p-dioxin and dibenzofuran formation from the pyrolysis of printed circuit boards. Environmental Science & Technology,2007,41(3):957-962 被引 3    
引证文献 1

1 梅俊 市政垃圾焚烧飞灰中添加CaO抑制PCDD/Fs生成试验探究 环境监测管理与技术,2020,32(5):48-51
被引 0 次

显示所有1篇文献

论文科学数据集
PlumX Metrics
相关文献

 作者相关
 关键词相关
 参考文献相关

版权所有 ©2008 中国科学院文献情报中心 制作维护:中国科学院文献情报中心
地址:北京中关村北四环西路33号 邮政编码:100190 联系电话:(010)82627496 E-mail:cscd@mail.las.ac.cn 京ICP备05002861号-4 | 京公网安备11010802043238号