帮助 关于我们

返回检索结果

生物滴滤塔耦合光催化氧化技术处理电子垃圾拆解车间排放废气的中试研究
Pilot-scale study on waste gas treatment from e-waste dismantling by combined technique of biological trickling filter with photocatalytic oxidation

查看参考文献20篇

黄勇 1   陈江耀 1   李建军 2   廖东奇 2   李桂英 1   安太成 1 *  
文摘 采用生物滴滤塔(BTF)与光催化一体化(PCO)联用工艺应用于电子垃圾拆解现场废气处理的中试研究,研究结果表明:电子垃圾拆解现场排放的废气中含有高浓度的总悬浮颗粒物(TSP)和挥发性有机污染物(VOCs)。其中TSP的质量浓度为3792.5~7387.9 μg·m~(-3),远高于中国环境空气质量控制标准(GB3095-2012)的二级标准(300 μg·m~(-3));VOCs主要由芳香烃类VOCs、含氮含氧类VOCs、卤代烃类VOCs和脂肪烃类VOCs组成,总VOCs的质量浓度为(5499.1±854.7)~(26834.0±447.0) μg·m~(-3),其中芳香烃类VOCs含量最高,其质量浓度为(2369.9±359.8)~(24 419.6±229.5) μg·m~(-3),其次是含氮含氧类VOCs和卤代烃类VOCs,分别为(1018.2±142.1)~(2144.2±167.5)和(1170.6 ±146.5)~(1936.6±353.3) μg·m~(-3),脂肪烃类VOCs的质量浓度最低,只有(44.6±0.8)~(174.4±0.5) μg·m~(-3)。相较单一BTF和PCO工艺,BTF-PCO联用工艺可以更为有效地去除电子垃圾拆解现场排放废气中的TSP和VOCs。研究结果表明,经过BTF-PCO处理后,出口TSP的质量浓度降低到747.4~1750.9 μg·m~(-3),其去除率在76.3%以上,而对于VOCs来说,出口浓度下降更为明显,芳香烃类VOCs、含氮含氧类VOCs、卤代烃类VOCs和脂肪烃类VOCs的去除率分别大于或者等于97.0%、92.4%、83.4%和100%。
其他语种文摘 Pilot-scale study of removal of e-waste dismantling waste gas by combined technique of biological trickling filter (BFT) and photocatalytic oxidation (PCO) were conducted in the work. Results showed that high concentrated total suspended particulate (TSP) and volatile organic compounds (VOCs) were detected from the emitted gas from e-waste dismantling process. The concentration of TSP was in the range of 3792.5 to 7387.9 μg·m~(-3), which was much higher than 3rd grade value of Chinese ambient air quality control criteria (500 μg·m~(-3)). And VOCs were mainly composed of aromatic, oxygenated and nitrogenated, halogenated and aliphatic VOCs with the concentration between 5499.1±854.7 and 26834.0±447.0 μg·m~(-3). Among these four kind of VOCs, aromatic VOCs account for the highest content with the concentration of 2369.9 ± 359.8 to 24419.6±229.5 μg·m~(-3), followed with oxygenated and nitrogenated VOCs, and halogenated VOCs with the concentrations ranged from 1018.2±142.1~2144.2±167.5 μg·m~(-3) and 1170.6±146.5~1936.6±353.3 μg·m~(-3). The concentration of aliphatic VOCs was the lowest of 44.6±0.8 and 174.4±0.5 μg·m~(-3). Compared with single BTF and PCO, BTF-PCO combined technique displayed more effective capability in the removal of both TSP and VOCs emitted from e-waste dismantling process. It was found that the concentration of TSP greatly decreased to 747.4~1750.9 μg·m~(-3) after BTF-PCO treatment with the removal efficiency of more than 76.3%. In the case of VOCs, the removal efficiencies are equal to or higher than 97.0%,92.4%,83.4% and 100% for aromatic, oxygenated and nitrogenated, halogenated and aliphatic VOCs, respectively.
来源 生态环境学报 ,2014,23(5):817-823 【核心库】
关键词 电子垃圾 ; 总悬浮颗粒物 ; 挥发性有机物 ; 生物技术 ; 光催化氧化 ; 中试研究
地址

1. 中国科学院广州地球化学研究所, 有机地球化学国家重点实验室;;广东省环境资源利用与保护重点实验室, 广东, 广州, 510640  

2. 广东省微生物研究所, 广东省菌种保藏与应用重点实验室, 广东, 广州, 510070

语种 中文
文献类型 研究性论文
ISSN 1674-5906
学科 行业污染、废物处理与综合利用
基金 广东省自然科学基金研究团队项目 ;  国家自然科学基金项目 ;  佛山市院市合作项目 ;  广东省科技计划项目
文献收藏号 CSCD:5208993

参考文献 共 20 共1页

1.  An T C. Comparison of the removal of ethanethiol in twin-biotrickling filters inoculated with strain RG-1 and B350 mixed microorganisms. Journal of Hazardous Materials,2010,183(1/3):372-380 被引 8    
2.  An T C. On-site and off-site atmospheric PBDEs in an electronic dismantling workshop in south China: Gas-particle partitioning and human exposure assessment. Environmental Pollution,2011,159(12):3529-3535 被引 3    
3.  Deng W J. Atmospheric levels and cytotoxicity of PAHs and heavy metals in TSP and PM_(2.5) at an electronic waste recycling site in southeast China. Atmospheric Environment,2006,40(36):6945-6955 被引 35    
4.  He Z G. Treatment of organic waste gas in a paint plant by combined technique of biotrickling filtration with photocatalytic oxidation. Chemical Engineering Journal,2012,200:645-653 被引 7    
5.  Li G Y. Distribution profile, health risk and elimination of model atmospheric SVOCs associated with a typical municipal garbage compressing station in Guangzhou, South China. Atmospheric Environment,2013,76:173-180 被引 2    
6.  Li G Y. Pollution profiles, health risk of VOCs and biohazards emitted from municipal solid waste transfer station and elimination by an integrated biological-photocatalytic flow system: A pilot-scale investigation. Journal of Hazardous Materials,2013,250:147-154 被引 6    
7.  Li H R. Severe PCDD/F and PBDQ/F pollution in air around an electronic waste dismantling area in China. Environmental Science & Technology,2007,41(16):5641-5646 被引 24    
8.  Paca J. Interactions of hydrophobic and hydrophilic solvent component degradation in an air-phase biotrickling filter reactor. Environmental Progress,2006,25(4):365-372 被引 2    
9.  Peng P A. The Pollution by Electronic and Electric Wastes. Progress in Chemistry,2009,21(2/3):550-557 被引 1    
10.  Zhang D L. Source identification and health risk of polycyclic aromatic hydrocarbons associated with electronic dismantling in Guiyu town, South China. Journal of Hazardous Materials,2011,192(1):1-7 被引 2    
11.  Sempere F. Performance evaluation of a biotrickling filter treating a mixture of oxygenated VOCs during intermittent loading. Chemosphere,2008,73(9):1533-1539 被引 12    
12.  Wong M H. Export of toxic chemicals-A review of the case of uncontrolled electronic-waste recycling. Environmental Pollution,2007,149(2):131-140 被引 83    
13.  陈江耀. 持久性有机污染物的污染状况及处置技术. 工业安全与环保,2008,34(5):40-42 被引 2    
14.  陈江耀. 光催化与生物技术联用工艺处理油漆废气中试研究. 环境工程学报,2010,4(6):1389-1393 被引 7    
15.  陈勇. 吹扫捕集-气相色谱质谱法分析土壤和沉积物中挥发性有机物. 中国环境监测,2011,27(6):26-30 被引 4    
16.  林海鹏. 兰州市某城区冬夏季大气颗粒物及重金属的污染特征. 中国环境科学,2012,32(5):810-815 被引 47    
17.  马兴元. 轻质陶粒滤料生态滤床的挂膜与启动研究. 生态环境学报,2009,18(6):2118-2121 被引 13    
18.  孙佩石. 生物降解工业废气中甲苯的研究. 环境科学动态,1996,3:13-16 被引 1    
19.  汪群慧. 生物滴滤塔处理青霉素车间VOCs中试研究. 哈尔滨工业大学学报,2006,38(12):2089-2093 被引 2    
20.  周启星. 我国主要电子垃圾处理地环境污染与人体健康影响. 安全与环境学报,2013,13(5):122-128 被引 3    
引证文献 4

1 曹春 生物滴滤法处理喷漆废气 化工环保,2015,35(3):288-292
被引 1

2 李子成 光降解催化剂及其应用研究进展 化工新型材料,2018,46(10):57-62
被引 3

显示所有4篇文献

论文科学数据集
PlumX Metrics
相关文献

 作者相关
 关键词相关
 参考文献相关

版权所有 ©2008 中国科学院文献情报中心 制作维护:中国科学院文献情报中心
地址:北京中关村北四环西路33号 邮政编码:100190 联系电话:(010)82627496 E-mail:cscd@mail.las.ac.cn 京ICP备05002861号-4 | 京公网安备11010802043238号