热解条件对煤膨胀和球形度的影响
EFFECTS OF PYROLYSIS CONDITIONS ON SWELLING AND SPHERICITY PROPERTIES OF COALS
查看参考文献18篇
|
文摘
|
针对粉煤密相输运床气化技术,使用滴管炉对云南褐煤(YN)、山东次烟煤(SD)和内蒙烟煤(NM)进行快速升温热解实验,应用数字成像颗粒分析仪同时获得颗粒粒径和球形度,研究了不同煤阶、粒径、温度、预烘干除水对煤焦形貌参数的影响.结果表明:随着煤阶提高,热解膨胀度和球形度均提高, 1 273 K热解后YN褐煤因收缩和破碎,膨胀度为0.66;SD煤和NM煤的膨胀度均大于1;焦的球形度因热解软化,较原煤均略有提高;NM烟煤随着热解温度的提高,膨胀度降低,球形度先增加后减小;小粒径 NM煤颗粒的膨胀度和球形度均更高.干燥NM煤的膨胀度显著高于含水原煤,且随温度升高,膨胀度提高,变化规律与含水原煤相反;球形度随温度变化规律相似,但却低于原煤,预烘干除水对NM煤焦形貌的影响显著. |
|
其他语种文摘
|
For the development of dense phase transport gasification technology, lignite (YN), sub-bituminous (SD) and bituminous (NM) coals were pyrolyzed in a drop-tube furnace. A digital image particle analyzer was used to obtain both swelling ratio and sphericity simultaneously. The effects of coal rank, particle size, temperature and drying pretreatment on char morphology were studied. With the increase of coal rank, the swelling ratio and sphericity were both increased. YN lignite underwent an obvious shrinkage with swelling ratio about 0. 66 after the 1 273 K pyrolysis. SD sub-bituminous and NM bituminous were more than 1. The particle sphericity was increased after pyrolysis because of the softening. With the increase of pyrolysis temperature, the swelling ratio of NM coal decreased, and the sphericity increased first and decreased then. Finer NM coal particles resulted in higher swelling and roundness. The swelling ratio of dried NM coal chars were higher, and increased with a higher pyrolysis temperature, which is contrary to the raw coals with moisture. The variation of sphericity with temperature was similar to the raw coal but the sphericity of dried coal char was lower than the raw coal. Drying pretreatment before pyrolysis experiments could significantly influence the morphology of chars. |
|
来源
|
煤炭转化
,2014,37(1):32-36 【核心库】
|
|
关键词
|
热解
;
煤颗粒
;
膨胀
;
形貌
;
球形度
|
|
地址
|
工程热物理研究所, 中国科学院先进能源动力重点实验室, 北京, 100190
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
1004-4248 |
|
学科
|
化学工业 |
|
基金
|
国家自然科学基金资助项目
;
中国科学院战略性先导科技专项
;
中国科学院知识创新工程重要方向项目
|
|
文献收藏号
|
CSCD:5060078
|
参考文献 共
18
共1页
|
|
1.
倪维斗. 以煤气化为核心的多联产能源系统--资源/能源/环境整体优化与可持续发展.
煤化工,2003(1):3-10
|
被引
18
次
|
|
|
|
|
2.
肖云汉. 煤炭多联产技术和氢能技术.
华北电力大学学报,2004,31(6):5-9
|
被引
5
次
|
|
|
|
|
3.
肖云汉.
煤粉加压密相输运床气化方法及装置:中国,ZL200710063702.4,2011
|
被引
1
次
|
|
|
|
|
4.
Solomon P R. Impact of Coal Pyrolysis on Combustion.
Symposium (International) on Combustion. 25(1),1994:463-474
|
被引
1
次
|
|
|
|
|
5.
金涌.
流态化工程原理,2001:26-29
|
被引
2
次
|
|
|
|
|
6.
Fletcher T H. Swelling Properties of Coal Chars During Rapid Pyrolysis and Combustion.
Fuel,1993,72(11):1485-1495
|
被引
1
次
|
|
|
|
|
7.
范晓雷. 热解条件对煤焦气化活性影响的研究进展.
煤炭转化,2005(3):74-79
|
被引
17
次
|
|
|
|
|
8.
Shurtz R C. Coal Swelling Model for Pressurized High Particle Heating Rate Pyrolysis Applications.
Energy and Fuels,2012,26(6):3612-3627
|
被引
2
次
|
|
|
|
|
9.
Zeng D. Swelling Properties and Intrinsic Reactivities of Coal Chars Produced at Elevated Pressures and High Heating Rates.
Proceedings of the Combustion Institute,2005,30(2):2213-2221
|
被引
6
次
|
|
|
|
|
10.
Gao H. Experimental Observation and Image Analysis for Evaluation of Swelling and Fluidity of Single Coal Particles Heated with C02 Laser.
Energy and Fuels,1997,11(3):730-738
|
被引
3
次
|
|
|
|
|
11.
Tsai C. The Structural Changes of Bituminous Coal Particles During the Initial Stages of Pulverized-coal Combustion.
Fuel,1987,66(2):200-206
|
被引
5
次
|
|
|
|
|
12.
Zygourakis K. Effect of Pyrolysis Conditions on the Macropore Structure of Coal-derived Chars.
Energy and Fuels,1993,7(1):33-41
|
被引
3
次
|
|
|
|
|
13.
Mitchell R E.
Compilation of Sandia Coal Char Combustion Data and Kinetic Analysis,1992
|
被引
1
次
|
|
|
|
|
14.
Lee C W. Effect of Pressure on the Devolatilization and Swelling Behaviour of a Softening Coal During Rapid Heating.
Fuel,1991,70(8):957-965
|
被引
6
次
|
|
|
|
|
15.
Gale T K. Decreases in the Swelling and Porosity of Bituminous Coals During Devolatilization at High Heating Rates.
Combustion and Flame,1995,100(1/2):94-100
|
被引
5
次
|
|
|
|
|
16.
李鹏云. 典型烟煤热解焦炭结构特性的实验研究.
煤炭转化,2010,33(3):68-71
|
被引
1
次
|
|
|
|
|
17.
Yu J. Swelling Behaviour of Individual Coal Particles in the Single Particle Reactor.
Fuel,2003,82(15/17):1977-1987
|
被引
3
次
|
|
|
|
|
18.
Shurtz R C. Coal Swelling Model for High Heating Rate Pyrolysis Applications.
Energy and Fuels,2011,25(5):2163-2173
|
被引
2
次
|
|
|
|
|
了解气象卫星更多信息，请访问