帮助 关于我们

返回检索结果

Influence of Hydrogen on GBF in Very High Cycle Fatigue of High Strength Steel

查看参考文献20篇

文摘 The relationship of hydrogen,GBF (granular bright facet) and very high cycle fatigue properties of high strength spring steels 60Si2CrV with three different hydrogen contents were studied using hydrogen thermal desorption analysis and ultrasonic fatigue test. The results showed that the influence of hydrogen on the relationship between fatigue life and the ratio of GBF to inclusion size [(A_(GBF))~(1/2)/(A_(INC))~(1/2)] was obvious, and the expression between fatigue life and [(A_(GBF))~(1/2)/(A_(INC))~(1/2)] with different hydrogen contents can also be obtained. In addition, based on the research of hydrogen diffusion and GBF, it was explained why the GBF cannot form below 10~6 cycles. At last, the estimated critical fatigue life of GBF formation can be expressed accurately.
来源 Journal of Iron and Steel Research , International,2013,20(12):92-97 【核心库】
DOI 10.1016/s1006-706x(13)60221-6
关键词 hydrogen ; granular bright facet ; very high cycle fatigue
地址

1. Central Iron and Steel Research Institute, National Engineering Research Center of Advanced Steel Technology, Beijing, 100081  

2. Faculty of Materials and Metallurgical Engineering, Northeastern University, Liaoning, Shenyang, 110819

语种 英文
文献类型 研究性论文
ISSN 1006-706X
学科 冶金工业
文献收藏号 CSCD:5021212

参考文献 共 20 共1页

1.  Shiozawa K. S-N curve Characteristics and Subsurface Crack Initiation Behaviour in Ultra-long Life Fatigue of a High Carbon-Chromium Bearing Steel. Fatigue Fract Engng Mater Struc,2001,24(12):781 被引 49    
2.  Murakami Y. Factors Influencing the Mechanism of Superlong Fatigue Failure in Steels. Fatigue Fract Engng Mater Struct,1999,22(7):581 被引 46    
3.  Wang Q Y. High-Cycle Fatigue Crack Initiation and Propagation Behaviour of High-Strength Spring Steel Wires. Fatigue Fract Engng Mater Struct,1999,22:673 被引 32    
4.  Shiozawa K. Subsurface Crack Initiation and Propagation Mechanism in High-Strength Steel in a Very High Cycle Fatigue Regime. Int. J. Fatigue,2006,28(11):1521 被引 42    
5.  Huang Z. Subsurface Crack Initiation and Propagation Mechanisms in Gigacycle Fatigue. Acta Metall Mater,2010,58(18):6046 被引 1    
6.  Sakai T. Characteristics S-N Properties of High Carbon Chromium Bearing Steel Under Axial Loading in Long Life Fatigue. Fatigue Fract Engng Mater Struct,2002,25(1):765 被引 51    
7.  Li W. Reliability Evaluation on Very High Cycle Fatigue Property of GCr15 Bearing Steel. Int. J. Fatigue,2010,32(7):1096 被引 14    
8.  Murakami Y. Mechanism of Fatigue Failure in Ultralong Life Regime. Fatigue Fract Engng Mater Struct,2002,25(8/9):735 被引 44    
9.  Takai K. Identification of Trapping Sites in High-Strength Steels by Secondary Ion Mass Spectrometry for Thermally Desorbed Hydrogen. Journal of the Japan Institute of Metals,1996,60(12):1155 被引 7    
10.  Li S X. Very High Cycle Fatigue Properties of High Strength Steels-Effects of Nonmetallic Inclusions. (in Chinese),2010 被引 1    
11.  Chapetti M D. Ultra-long Cycle Fatigue of High-Strength Carbon Steels Part I: Review and Analysis of the Mechanism of Failure. Materials Science and Engineering. A,2003,356(1):227 被引 17    
12.  Billaudeau T. Support for an Environmental Effect on Fatigue Mechanisms in the Long Life Regime. Int. J. Fatigue,2004,26(8):839 被引 2    
13.  Li Y D. The Influence of Hydrogen on Very High Cycle Fatigue Properties of High Strength Spring Steel. Materials Science and Engineering. A,2008,489(1):373 被引 9    
14.  Furuya Y. Gigacycle Fatigue Properties of Hydrogen-Charged JIS-SCM440 Low-Alloy Steel Under Ultrasonic Fatigue Testing. Metall Mater Trans. A,2010,41(9):2248 被引 4    
15.  Liu Y B. Factors Influencing the GBF Size of High Strength Steels in the Very High Cycle Fatigue Regime. Materials Science and Engineering. A,2011,528:935 被引 7    
16.  Carneiro Filho C J. The Effect of Hydrogen Release at Room Temperature on the Ductility of Steel Wire Rods for Pre-Stressed Concrete. Materials Science and Engineering. A,2010,527(18/19):4947 被引 14    
17.  Chapetti M D. Ultra-long Cycle Fatigue of High-Strength Carbon Steels Part II: Estimation of Fatigue Limit for Failure From Internal Inclusions. Materials Science and Engineering. A,2003,356(1):236 被引 24    
18.  Nagao A. Visualization of Hydrogen Transport in High Strength Steels Affected by Stress Fields and Hydrogen Trapping. Scripta Materialia,2001,45(10):1227 被引 5    
19.  Yu Y. Very High Cycle Fatigue Mechanism of Carbide-Free Bainite/ Martensite Steel. Materials Science and Engineering. A,2009,527(1):212 被引 3    
20.  Yang Z G. Estimation of the Size of GBF Area on Fracture Surface for High Strength Steels in Very High Cycle Fatigue Regime. Int. J. Fatigue,2008,30(6):1016 被引 14    
引证文献 1

1 宋亚南 金属材料超高周疲劳的试验方法及失效特征 中国有色金属学报,2015,25(12):3245-3254
被引 3

显示所有1篇文献

论文科学数据集
PlumX Metrics
相关文献

 作者相关
 关键词相关
 参考文献相关

版权所有 ©2008 中国科学院文献情报中心 制作维护:中国科学院文献情报中心
地址:北京中关村北四环西路33号 邮政编码:100190 联系电话:(010)82627496 E-mail:cscd@mail.las.ac.cn 京ICP备05002861号-4 | 京公网安备11010802043238号