低比转速复合叶轮离心泵内的非定常流动特性
Unsteady flow characteristics in low-specific-speed centrifugal pump with complex impeller
查看参考文献16篇
|
文摘
|
为了研究低比转速离心泵内由叶轮/蜗壳相互作用所引起的非定常流动特性，基于滑移网格和RNGκ-ε湍流模型计算了具有4长8短复合叶轮离心泵内部的非定常流动.计算结果显示，离心泵内部速度和压力在空间上呈现高度非对称性，在时间上呈现高度非定常性.蜗壳第Ⅳ断面和第Ⅷ断面速度变化规律基本一致，周向速度沿蜗壳径向减小，第Ⅷ断面出现负的径向速度，流动最为复杂.叶轮和蜗壳的动静耦合是产生压力脉动的主要原因，压力脉动的频率受叶轮转频控制，主频为叶片通过频率.蜗壳周向的脉动压力幅值呈现上下波动，但从第Ⅰ断面到第Ⅷ断面其幅值整体上在逐渐衰退，直到蜗壳第Ⅷ断面达到最小.与定常计算相比，在设计点下非定常计算所得的有效扬程更接近实验值，说明非定常计算可以比较准确地预测泵的扬程。 |
|
其他语种文摘
|
To investigate the unsteady flow characteristics caused by interaction between the impeller and volute in the low-specific-speed centrifugal pump, the unsteady flow field of a centrifugal pump with fourlong and eight-short blades was simulated based on sliding mesh and RNG k-εturbulence model. The simulation results of velocity and static pressure show highly asymmetric in space as well as highly unsteady in time. The velocities on sectionsⅣandⅧof volute have the same trend, and the circumferential velocity decreases along the radial direction of volute. The change of radial velocity magnitude on sectionⅣis less than that on sectionⅧbecause sectionⅣis away from the tongue and is less influenced. The flow near the volute is the most complex and the radial negative velocity appears on sectionⅧ. The rotor-stator coupling is the main reason for pressure fluctuation, whose frequency is dominated by impeller rotating frequency, and the dominant frequency is blade passing frequency. The amplitude of fluctuation pressure along the volute fluctuates from sectionⅠto sectionⅧ, and its average value declines gradually until sectionⅧreaches a minimumvalue. Compared with the steady calculation, the effective head calculated by unsteady calculation is closer to experimental value at design point, indicating that the unsteady calculations can predict the pump head accurately. |
|
来源
|
化工学报
,2011,62(11):3093-3100 【核心库】
|
|
DOI
|
10.3969/j.issn.0438-1157.2011.11.017
|
|
关键词
|
离心泵
;
低比转速
;
复合叶轮
;
非定常
;
数值模拟
|
|
地址
|
1.
浙江理工大学流体传输及应用实验室, 浙江, 杭州, 310018
2.
浙江天德泵业有限公司, 浙江, 苍南, 325800
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
0438-1157 |
|
学科
|
机械、仪表工业 |
|
基金
|
国家自然科学基金项目
;
浙江省自然科学基金
|
|
文献收藏号
|
CSCD:4347539
|
参考文献 共
16
共1页
|
|
1.
Rzentkowski G. Acoustic characterization of a CANDU primary heat transport pump at the blade-passing frequency.
Nuclear Engineering Design,2000,196:63-68
|
被引
2
次
|
|
|
|
|
2.
徐洁. Numerical calculation of flow field in centrifugal impeller with splitter blades.
化工学报,2004,55(4):542-544
|
被引
2
次
|
|
|
|
|
3.
刘在伦. 复合叶轮对高速部分流泵性能的影响.
流体机械,2010,38(4):38-41
|
被引
3
次
|
|
|
|
|
4.
崔宝玲. 长中短叶片离心叶轮内部流动的数值模拟.
推进技术,2006,27(3):243-247
|
被引
5
次
|
|
|
|
|
5.
Dolcu Mustafa. Energy saving in a deep well pump with splitter blade.
Energy Conversion and Management,2006,47:638-651
|
被引
1
次
|
|
|
|
|
6.
Derakhshan Shahram. Theoretical, numerical and experimental investigation of centrifugal pumps in reverse operation.
Experimental Thermal and Fluid Science,2008,32:1620-1627
|
被引
42
次
|
|
|
|
|
7.
Hiroyuki Miyamoto. Effects of splitter blades on the flows and characteristics in centrifugal impeller.
JSME International SeriesⅡ,1992,35(2):238-246
|
被引
1
次
|
|
|
|
|
8.
徐朝晖. 基于滑移网格与RNG湍流模型计算泵内的动静干扰.
工程热物理学报,2005,26(1):66-68
|
被引
22
次
|
|
|
|
|
9.
王洋. 离心泵内部不稳定流场压力脉动特性分析.
农业机械学报,2010,41(3):91-95
|
被引
27
次
|
|
|
|
|
10.
耿少娟. Numerical study of unsteady flow in centrifugal pump with different type of impellers.
机械工程学报,2006,42(5):28-31
|
被引
1
次
|
|
|
|
|
11.
陈党民. Numerical analysis of unsteady flow field for partial emission pump.
西安交通大学学报,2005,39(9):957-957
|
被引
1
次
|
|
|
|
|
12.
杨从新. 3-D numerical simulation on transient characteristics of centrifugal pump during starting period.
排灌机械工程学报,2010,28(2):122-126
|
被引
8
次
|
|
|
|
|
13.
Parrondo-Gayo Jorge L. The effect of the operating point on the pressure fluctuations at the blade passage frequency in the volute of a centrifugal pump.
Transactions of the ASME,2002,123(9):466-474
|
被引
3
次
|
|
|
|
|
14.
Shi F. Numerical study of pressure fluctuations caused by impeller-diffuser interaction in a diffuser pump stage.
Transactions of the ASME,2001,123(9):466-474
|
被引
6
次
|
|
|
|
|
15.
Yakhot Victor. Renormalization group analysis of turbulence (Ⅰ): Basic theory.
Journal of Scientific Computing,1986,1(1):3-5
|
被引
509
次
|
|
|
|
|
16.
李进良.
Proficient FLUENT 6.3 Flow Analysis,2009
|
被引
1
次
|
|
|
|
|
了解气象卫星更多信息，请访问