喷射式外环流反应器的液-液传质性能
Liquid-liquid mass transfer performance of jet external loop reactor
查看参考文献17篇
|
文摘
|
利用水-醋酸-煤油体系,研究了喷射式外环流反应器的传质性能,得到了反应器结构参数与物料流率等对传质性能的影响规律.根据反应器中的流体动力学特性,将反应器划分为底部区域,预混区,混合区,环流区和分离区.反应器底部区域几乎为水相,其传质性能可以忽略.首先利用实验数据回归得到了醋酸在水相中的平衡浓度与其在油相中初始浓度的经验关系式,之后分别研究了反应器内其他4个区域的传质性能.反应器各区域的传质性能均随油相表观进料速率和水相表观进料速率的增大而提高,在混合区内设分配管可显著提高反应器各个区域的传质性能,且分配管进料速率越大,传质性能越好.相同实验条件下,各区域的体积传质系数由大到小的顺序为:预混区,混合区,环流区,分离区 |
|
其他语种文摘
|
This paper studies the mass transfer performance of the jet external loop reactor using the water-HAc-kerosene system and the effect of the section structure of the reactor and the material velocity on the mass transfer performance. The loop reactor is divided into five sections according to the hydrodynamic characteristics, which are bottom, premixing, mixing, looping and separation sections. There is almost water phase in the bottom section and its mass transfer could be neglected. An empirical expression between the equilibrium concentration of HAc in water phase and the initial concentration of HAc in oil phase was obtained by the regression of experimental data. And then the mass transfer performance of the other four sections was researched. The results show that the mass transfer performance of all sections increased as the superficial velocity of both oil and water phases went up. The mass transfer performance of all sections could be greatly increased by feeding in the distributing pipe. And the higher the velocity in the distributing pipe, the better the mass transfer performance. The mass transfer coefficient of four sections with a sequence from large to small under the same condition was as follows, premixing section, mixing section, looping section, and separation section |
|
来源
|
化工学报
,2010,61(9):2320-2327 【核心库】
|
|
关键词
|
环流反应器
;
传质
;
分配管
;
表观速率
|
|
地址
|
中国石油大学(北京), 重质油国家重点实验室, 北京, 102249
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
0438-1157 |
|
学科
|
化学工业 |
|
基金
|
国家自然科学基金项目
|
|
文献收藏号
|
CSCD:3992084
|
参考文献 共
17
共1页
|
|
1.
朱慧红. Study and progress on loop reactor for the system of gas-liquid-solid three phases.
化工科技,2003,11(4):48-52
|
被引
3
次
|
|
|
|
|
2.
董永刚. Research status and prospect of airlift loop reactor.
现代机械,2009(4):85-89
|
被引
1
次
|
|
|
|
|
3.
Heijnen J J. A simple hydrodynamic model for the liquid circulation velocity in a full-scale two-and three-phase internal airlift reactor operating in the gas recirculation regime.
Chem. Eng. Sci,1997,52(15):2527-2540
|
被引
25
次
|
|
|
|
|
4.
Couvert A. Two-phase hydrodynamic study of a rectangular air-lift loop reactor with an internal baffle.
Chemical Engineering Science,1999,54(21):5245-5252
|
被引
9
次
|
|
|
|
|
5.
张同旺. 三相环流反应器流体力学行为.
化工学报,2005,56(7):1213-1217
|
被引
6
次
|
|
|
|
|
6.
李飞. 新型多级环流反应器流体力学研究.
化学工程,2006,34(2):37-40
|
被引
4
次
|
|
|
|
|
7.
刘梦溪. 环隙气升式气固环流反应器内流体力学特性的理论分析.
化工学报,2008,59(9):2198-2205
|
被引
9
次
|
|
|
|
|
8.
Lu X P. Comparison of the hydrodynamics and mass transfer characteristics of a modified square airlift reactor with common airlift reactors.
Chem. Eng. Sci,2000,55(12):2257-2263
|
被引
18
次
|
|
|
|
|
9.
Fadavi A. Gas-liquid mass transfer in a novel forced circulation loop reactor.
Chem. Eng. J,2005,112(1/2/3):73-80
|
被引
3
次
|
|
|
|
|
10.
Wen J P. Local overall Gasliquid mass transfer coefficient in a gas-liquid-solid reversed flow jet loop reactor.
Chem. Eng. J,2002,88(1/2/3):209-213
|
被引
7
次
|
|
|
|
|
11.
谷奎庆. 三相连续环流反应器中氧的液相传质过程.
过程工程学报,2007,7(5):847-852
|
被引
3
次
|
|
|
|
|
12.
Mudde R F. 2D and 3D simulations of an internal airlift loop reactor on the basis of a two-fluid model.
Chem. Eng. Sci,2001,56(21/22):6351-6358
|
被引
17
次
|
|
|
|
|
13.
Roy S. CFD simulation of flow and axial dispersion in external loop airlift reactor.
Chem. Eng. Res. Des,2006,84(8):677-690
|
被引
5
次
|
|
|
|
|
14.
张红. 外环流反应器的流动与局部传质特性研究.
石油化工高等学校学报,2002,15(3):9-11
|
被引
3
次
|
|
|
|
|
15.
刘永民. 气升式外环流反应器的传质特性.
石油学报:石油加工,2003,19(6):70-74
|
被引
3
次
|
|
|
|
|
16.
张红. Volumetric mass transfer coefficient in external loop airlift reactor.
Chemical Engineering,2004,32(4):35-37
|
被引
1
次
|
|
|
|
|
17.
周建军. 新型烷基化反应器结构优化及其中液滴分布规律的实验研究.
石油学报:石油加工,2008,24(2):134-140
|
被引
2
次
|
|
|
|
|
了解气象卫星更多信息，请访问