煤拔头半焦燃烧特性
Combustion Characteristics of Char from Coal Topping Process
查看参考文献17篇
文摘
|
利用喷动载流床模拟煤拔头工艺,在550,650,750和850℃温度下对大同烟煤进行热解得到拔头半焦,采用非等温热分析方法对原煤及拔头半焦的燃烧特性进行了研究.由热分析实验数据归纳提出了表征煤和半焦着火、燃烧及燃烬性能的无量纲综合燃烧指数Z.Z值越大,煤样综合燃烧性能越佳.结果显示,大同烟煤在2℃/min升温速率下Z值为0.41;4个热解温度(由低到高)下所得拔头半焦的Z值分别为0.39,0.35,0.31,0.21,且拔头半焦的燃烧性能均低于原煤,但高于阳泉无烟煤,且随热解温度升高Z值降低,燃烧反应性降低.Z值与着火温度及表观燃烧活化能表现出的反应性一致. |
其他语种文摘
|
Different chars have been prepared from Datong coal with the spouted bed reactor at four pyrolysis temperatures, 550, 650, 750 and 850℃. The influence of pyrolysis temperature on the combustion characteristics of different chars is studied using a thenno-gravimetric device. A new dimensionless combustion index Z has been proposed to describe the combustion behavior of coal and char. The higher the Z value, the better the combustion behavior. Under the condition of 2℃/min heating rate for example, the Z value of Datong raw coal is 0.41, that of Yangquan anthracite 0.12, and Z values of chars at four pyrolysis temperatures, 550, 650, 750 and 850℃, respectively are 0.39, 0.35, 0.31, 0.21. The combustion reactivity of different chars is lower than that of Datong raw coal, but higher than that of Yangquan anthracite. For different chars, with the increasing of pyrolysis temperature the Z decreases, the combustion behavior becomes worse, which agrees with the variation of ignition temperature and apparent combustion activation energy. |
来源
|
过程工程学报
,2009,9(5):897-903 【核心库】
|
关键词
|
半焦
;
着火温度
;
燃烧指数
;
动力学参数
|
地址
|
1.
中国科学院过程工程研究所, 多相复杂系统国家重点实验室, 北京, 100190
2.
哈尔滨工业大学能源科学与工程学院, 黑龙江, 哈尔滨, 015001
|
语种
|
中文 |
文献类型
|
研究性论文 |
ISSN
|
1009-606X |
学科
|
化学工业 |
基金
|
国家863计划
;
国家自然科学基金
|
文献收藏号
|
CSCD:3744514
|
参考文献 共
17
共1页
|
1.
郭幕孙.
循环流态化碳氢固体燃料的四联产工艺及装置.中国专利:ZL01110152.0,2002
|
被引
1
次
|
|
|
|
2.
陈建原. 煤的挥发分释放特性指数和燃烧特性指数的确定.
动力工程,1987(5):13-18
|
被引
16
次
|
|
|
|
3.
魏兆龙. 煤种燃烧稳定性实验研究.
锅炉技术,1999,30(10):6-9
|
被引
4
次
|
|
|
|
4.
谢峻林. 水泥分解炉工况下煤焦的燃尽动力学过程研究.
燃料化学学报,2002,30(3):223-228
|
被引
3
次
|
|
|
|
5.
方立军. 利用热天平对电厂混煤燃尽特性的实验研究.
华北电力技术,2001(1):7-9,24
|
被引
5
次
|
|
|
|
6.
高正阳. 混煤燃烧特性的热重试验研究.
动力工程,2002,22(3):1764-1767,1749
|
被引
35
次
|
|
|
|
7.
韩洪樵. 用快速加热热天平研究煤的可燃性指标.
工程热物理学报,1990,11(3):342-345
|
被引
6
次
|
|
|
|
8.
崔丽杰.
煤热解过程中产物组成和官能团转化的研究,2005:40
|
被引
2
次
|
|
|
|
9.
喻秋梅. 煤燃烧实验中着火点确定方法的探讨.
华北电力技术,2001(7):9-10,50
|
被引
18
次
|
|
|
|
10.
周英彪. 基于热天平着火温度的新方法.
电站系统工程,2007,23(3):29-31
|
被引
5
次
|
|
|
|
11.
朱群益. 煤燃烧特征点变化规律的研究.
热能动力工程,1997,12(5):332-334,357
|
被引
7
次
|
|
|
|
12.
Loewenberg M. Combustion Behavior and Kinetics of Synthetic and Coal-derived Chars:Comparison of Theory and Experiment.
Combustion and Flame,1991,84(1/2):47-65
|
被引
1
次
|
|
|
|
13.
Smith I W. The Combustion Rates of Coal Chars:A Review.
Symposium (International) on Combustion,1982,19(1):1045-1065
|
被引
14
次
|
|
|
|
14.
Williams A. Modeling Coal Combustion:The Current Position.
FUEL,2002,81(5):605-618
|
被引
7
次
|
|
|
|
15.
王擎. 桦甸油页岩半焦燃烧反应动力学研究.
中国电机工程学报,2006,26(7):29-34
|
被引
28
次
|
|
|
|
16.
胡荣祖.
热分析动力学,2001:100-101
|
被引
4
次
|
|
|
|
17.
Yu J. Formation of the Structure of Chars during Devolatilization of Pulverized Coal and Its Thermoproperties:A Review.
Progress in Energy and Combustion Science,2007,33(2):135-170
|
被引
18
次
|
|
|
|
|