油田采油污泥的热解动力学及其热解效果研究
Study on pyrolysis kinetics and efficiency of oil exploitation sludge
查看参考文献8篇
文摘
|
以新疆克拉玛依油田采油污泥为对象,分别采用热重分析仪和小型流化床热解反应器研究了含油污泥的热解过程及其热解效果.结果表明,油泥热解主要经历了失水、轻质组分挥发、重组分快速热解失重和缓慢失重4个阶段,热解过程基本符合一级动力学方程,提高热解的升温速率,可使油泥的最大失重速率D_(max)、失重速率峰值温度θ_(max)、升温终点的最大失重率都随之增加,表现在动力学上,反映出表观活化能和碰撞频率因子的同时升高,即提高油泥热解转化率的同时也影响了热解效率.失水油泥用流化床热解,在热解温度600℃、反应时间3 min时,油泥回收率可达到87%. |
其他语种文摘
|
The pyrolysis process and efficiency of oil exploitation sludge in the Karamay Oilfield were studied with thermogravimetric analysis apparatus and a small fluidized bed pyrolysis reactor. The thermogravimetric results show that the oil sludge by pyrolysis has undergone four stages:water loss,the volatile of the lightweight components, rapid weight loss and slow weight loss. The study on the thermal dynamics shows that the pyrolysis of oil sludge accords generally with one reaction model. The characteristic parameters of pyrolysis: the largest weight loss rate, the temperature of the weight loss rate peak and the largest weight loss, increase following the heating rate increasing. The apparent activation energy and the frequency factor also increase at the same time in kinetics, which matches increasing conversion rate and pyrolysis efficiency of oil sludge. The results of the pyrolysis of dried oil sludge in fluidized bed show that the best conditions for pyrolysis are the reaction temperature 600 ℃ and reaction time 3 min. The recovery rate can reach 87%. |
来源
|
环境工程学报
,2009,3(5):932-936 【核心库】
|
关键词
|
热重分析
;
热解
;
含油污泥
;
流化床
|
地址
|
1.
陕西科技大学,资源与环境学院, 陕西, 西安, 710021
2.
中国科学院,过程工程研究所, 多相复杂系统国家重点实验室, 北京, 100190
3.
中国科学院,新疆生态与地理研究所, 新疆, 乌鲁木齐, 830011
|
语种
|
中文 |
文献类型
|
研究性论文 |
ISSN
|
1673-9108 |
学科
|
行业污染、废物处理与综合利用 |
文献收藏号
|
CSCD:3588258
|
参考文献 共
8
共1页
|
1.
赵由才.
危险废物处理技术,2003:327
|
被引
1
次
|
|
|
|
2.
李君. 国内外含油污泥的处理现状分析.
能源环境保护,2007,21(5):12-14
|
被引
8
次
|
|
|
|
3.
王琼. 污水污泥的热解处理.
再生资源研究,2004(4):38-41
|
被引
6
次
|
|
|
|
4.
Takahiro Murakami. Some process fundamentals of biomass gasification in dual fluid-ized bed.
FUEL,2007,86:244-255
|
被引
2
次
|
|
|
|
5.
Mohammad Asadullah. Gasification of different biomasses in a dual-bed gasifier system combined with novel catalysts with high energy effi-ciency.
Applied Catalysis A:General,2004,267:95-102
|
被引
8
次
|
|
|
|
6.
于伯龄.
实用热分析,1988:156-158
|
被引
1
次
|
|
|
|
7.
Je-Lueng Shie. Re-sources recovery of oil sludge by pyrolysis:Kinetics study.
Journal of Chemical Technology and Biotechnology,2000,75:443-450
|
被引
3
次
|
|
|
|
8.
李余增.
热分析,1987:91-100
|
被引
8
次
|
|
|
|
|