湿法烟气脱硫系统对细颗粒脱除性能的实验研究
Performance of removal of fine particles by WFGD system
查看参考文献9篇
|
文摘
|
针对石灰石-石膏法、双碱法、氨法等典型湿法烟气脱硫(WFGD)工艺,在喷淋脱硫塔中实验研究了WFGD系统对细颗粒的脱除作用;采用电称低压冲击器、场发射扫描电镜、X射线衍射仪等对WFGD系统前后烟气中细颗粒的浓度、粒径分布、形态、元素及物相组成进行了测试分析,考察了脱硫剂、液气比对WFGD系统脱除细颗粒性能的影响,并进行了利用蒸汽相变原理促进细颗粒凝结长大并高效脱除的实验研究.结果表明,脱硫剂对WFGD系统脱除细颗粒的性能具有重要影响,由于形成无机盐气溶胶细颗粒,采用CaCO_3、NH_3·H_2O脱硫剂时,WFGD系统对细颗粒的脱除效果明显不及Na_2CO_3脱硫剂和水洗涤,且颗粒形貌特征及元素组成发生明显变化;除NH_3·H_2O脱硫剂外,液气比对WFGD系统脱除细颗粒的影响不明显;在脱硫塔进口烟气、塔内脱硫液进口上方添加适量蒸汽建立蒸汽相变所需的过饱和水汽环境可显著促进细颗粒的脱除. |
|
其他语种文摘
|
In a spray column scrubber, the removal of fine particles by wet flue gas desulfurization (WFGD) system was investigated experimentally for the typical WFGD process, such as limestone-gypsum double-alkali and ammonia-based process. The number concentration and size distribution, morphologies, elemental and phase composition of fine particles before and after desulfurization were measured by using an electrical low pressure impactor (ELPI), field emission scanning electron microscope/energy dispersive X-ray spectrometry ( FESEM-EDS) and X-ray diffraction (XRD), respectively. The influences of SO_2 absorbent and liquid-gas ratio on fine particles removal by the WFGD system were also investigated. Moreover, an experiment was carried out on the removal of fine particles with high efficiency by heterogeneous condensation of water vapor. The results showed that the removal effect of fine particles by the WFGD system was related to the SO_2 absorbent employed. When using CaCO_3 and NH_3·H_2O to remove SO_2 from flue gas, the fine particles removal efficiencies were lower than those for Na_2CO_3 and water, and the morphology and elemental composition of fine particles were changed. This effect could be attributed to the formation of aerosol particles in the limestone and ammonia-based FGD processes. The effect of liquid-to-gas ratio seemed to be relatively weak except for NH_3·H_2 O as absorbent. The performance of removal of fine particles by the WFGD system could be significantly improved by means of steam addition both in the gas inlet and above the scrubbing solutions inlet of the scrubber, in which the removal efficiency increased with increasing amount of added steam. |
|
来源
|
化工学报
,2009,60(5):1260-1267 【核心库】
|
|
关键词
|
湿法烟气脱硫
;
细颗粒
;
脱除
|
|
地址
|
东南大学能源与环境学院, 江苏, 南京, 210096
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
0438-1157 |
|
学科
|
环境污染及其防治 |
|
基金
|
国家自然科学基金
;
国家高技术研究发展计划(863计划)
|
|
文献收藏号
|
CSCD:3586243
|
参考文献 共
9
共1页
|
|
1.
王珲. 电厂湿法脱硫系统对烟气中细颗粒物脱除作用的实验研究.
中国电机工程学报,2008,27(5):1-7
|
被引
83
次
|
|
|
|
|
2.
Meij R. The emissions and environmental impact of PM 10 and trace elements from a modern coal-fired power plant equipped with ESP and wet FGD.
Fuel Processing Technology,2004,85(6/7):641-656
|
被引
65
次
|
|
|
|
|
3.
孙露娟. 洗涤塔脱除燃烧源超细颗粒的实验研究.
化工学报,2008,59(6):1508-1514
|
被引
11
次
|
|
|
|
|
4.
陈梅倩. 氨法脱硫反应特性的化学动力学分析.
环境科学学报,2005,25(7):886-890
|
被引
17
次
|
|
|
|
|
5.
Schaber K. Aerosol formation in gas-liquid contact devices-nucleation,growth and particle dynamics.
Chemical Engineering Science,2002,57(20):4345-4356
|
被引
1
次
|
|
|
|
|
6.
Gretscher H. Aerosol formation by heterogeneous nucleation in wet scrubbing processes.
Chemical Engineering and Processing,1999,38(4/5/6):541-548
|
被引
2
次
|
|
|
|
|
7.
Ehrig R. Modelling and simulation of aerosol formation by heterogeneous nucleation in gas-liquid cintact devices.
Chemical Engineering Science,2002,57(7):1151-1163
|
被引
3
次
|
|
|
|
|
8.
颜金培. 燃烧源PM2．5微粒润湿性能.
东南大学学报（自然科学版）,2006,36(5):760-764
|
被引
26
次
|
|
|
|
|
9.
张霞. Experimental study on removal of PM 2.5 from combustion by vapor heterogeneous condensation.
东南大学学报(自然科学版),2007,38(1):81-85
|
被引
3
次
|
|
|
|
|
了解气象卫星更多信息，请访问