Dynamic Model for Simulation and Control of Cement Rotary Kilns
用于仿真与控制的水泥回转窑动态模型
查看参考文献10篇
文摘
|
A dynamic mathematical model was developed for the simulation and control of cement rotary kilns. The model consists of a set of nonlinear partial differential equations, and represents the material and energy balances in the kiln. Based on some logical assumptions, the model does not only consider the reaction mechanisms but also reduces the complexity of computer simulation. The steady-state simulation shows that the behavior of the model is agreement with the results presented in the literature. Then several disturbances in the manipulated variables were tested and the dynamic response was analyzed. The good performance exhibited by the dynamic model makes it suitable for simulation and control studies as well as for optimization and design. |
其他语种文摘
|
建立了一个用于仿真与控制的水泥回转窑动态数学模型。该动态模型基于回转窑内的物料和能量平衡,由一组非线性偏微分方程组成。在合理的假设条件下,该模型不但考虑了反应机理,而且降低了仿真计算的复杂性。首先,稳态仿真表明模型稳态行为与文献中给出的结果是一致的;在此基础上,对操纵变量加入扰动测试并对动态响应进行了分析,结果表明该模型动态性能良好,适合于回转窑的仿真、控制以及优化设计的研究之用。 |
来源
|
系统仿真学报
,2008,20(19):5131-5135 【核心库】
|
关键词
|
dynamic
;
model
;
rotary
;
kiln
;
simulation
;
control
|
地址
|
Key Laboratory of Industrial Informatics,Shenyang Institute of Automation,Chinese Academy of Sciences, Shenyang, 110016
|
语种
|
英文 |
文献类型
|
研究性论文 |
ISSN
|
1004-731X |
学科
|
自动化技术、计算机技术 |
基金
|
国家863计划
|
文献收藏号
|
CSCD:3482529
|
参考文献 共
10
共1页
|
1.
Mintus F. Wet Process Rotary Cement Kilns:Modeling and Simulation.
Clean Tcchn. Environ. Policy(S1618-9558),2006,8(2):112-122
|
被引
1
次
|
|
|
|
2.
Mujumdar K S. Modeling of Rotary Cement Kilns:Applications to Reduction in Energy Consumption.
Ind. Eng. Chem. Res,2006,45(7):2315-2330
|
被引
5
次
|
|
|
|
3.
Mujumdar K S. Rotary Cement Kiln Simulator(Rocks):Integrated Modeling of Pre-Heater, Calciner, Kiln and Clinker Cooler.
Chemical Engineering Science(S0009-2509),2007,62(9):2590-2607
|
被引
15
次
|
|
|
|
4.
Luyben W L.
Process Modeling, Simulation and Control for Chemical Engineers,1990
|
被引
5
次
|
|
|
|
5.
Chert Q D.
The Principle and Application of New Dry Cement Technique(in Chinese),2004
|
被引
1
次
|
|
|
|
6.
Lyons J W. Experimentation with a Wet-Process Rotary Cement Kiln via the Analog Computer.
Ind. Eng. Chem. Pro. Des. Dev. (S0888-5885),1962,1(1):29-33
|
被引
3
次
|
|
|
|
7.
Spang H A. A Dynamic Model of a Cement Kiln.
Automatica(S0005-1098),1972,8(3):309-323
|
被引
2
次
|
|
|
|
8.
Bui R T. A Computer Model for the Cement Kiln.
IEEE Transactions on Industry Applications(S0093-9994),1982,IA/18(4):424-430
|
被引
3
次
|
|
|
|
9.
Mujumdar K S. Simulation of Rotary Cement Kilns Using a One-Dimensional Model.
Chemical Engineering Reasearch and Design(S0263-8762),2006,84(A3):165-177
|
被引
12
次
|
|
|
|
10.
Wang Z. Dynamic Model of Cement Precalcination Process.
Proceedings of the 27th IASTED International Conference on Modeling, Identification, and Control,2008:160-165
|
被引
1
次
|
|
|
|
|