牙用亚微米氧化锆增韧氧化铝陶瓷的摩擦磨损性能研究
Tribological Behavior of Submicron ZrO2 Particulates Toughened Al2O3 Dental Ceramic
查看参考文献16篇
文摘
|
考察了亚微米氧化锆增韧氧化铝陶瓷(Z2S)在人工唾液润滑下的摩擦磨损行为,并与目前口腔临床常用烤瓷材料Vita陶瓷和Dentsply陶瓷进行对比.结果表明:与Si3N4陶瓷配副时,Z2S的摩擦磨损性能优于Vita陶瓷和Dentsply陶瓷,其磨损率比Vita陶瓷和Dentsply陶瓷的磨损率低2个数量级,Z2S的主要磨损机制为轻微的磨粒磨损和塑性变形,并受ZrO2的摩擦诱导相变影响;与天然牙釉质配副时,Z2S不仅自身磨损低而且对天然牙釉质的磨损较小,天然牙釉质的磨损表面保持了较好的初始形态,其与天然牙釉质的配对性优于Dentsply陶瓷与天然牙釉质的配对性,是1种具有潜在应用前景的牙科修复材料. |
其他语种文摘
|
Tribological behaviors of submicron zirconia toughened alumina dental ceramic (Z2S) against Si3 N4 were investigated on a UMT tribo-meter with a ball-on-disk configuration under lubrication of artificial saliva. As comparison, the triblogical performances of Vita and Dentsply, which are currently used in dental clinic, were used as the baseline. Z2S exhibited better triboligical performance than Vita and Dentsply did, as analyzed from friction coefficient and wear rate. The most promising aspect for Z2S is the wear rate, which is two order lower than that of the two commercial ceramics. The worn surface of Z2S is mainly characterized by mild abrasive wear with plastically deformed grooves, rather than severe plastic deformation and micro-fracture, which are commonly found on the worn surfaces of Vita and Dentsply. The wear mechanism of Z2S under the tested conditions is probably friction-induced phase transformation of ZrO2. Additional experiments on the Z2S and Dentsply mated with human enamel were conducted. According to the friction and wear simulation, the Z2S/human enamel pair should be the good choice on the basis of the wear rates of the tribo-couple as well as the morphology of worn surface. The wear rate of Z2S is much lower than that of Dentsply, the initial microstructure of human enamel is well preserved as mated with Z2S while it is not as mated with Dentsply. Z2S shows potential application as dental all-ceramic. |
来源
|
摩擦学学报
,2006,26(3):264-269 【核心库】
|
关键词
|
亚微米氧化锆
;
增韧
;
氧化铝陶瓷
;
天然牙釉质
;
摩擦磨损性能
|
地址
|
1.
兰州大学口腔医学院口腔修复学研究室, 甘肃, 兰州, 730000
2.
中国科学院兰州化学物理研究所, 固体润滑国家重点实验室, 甘肃, 兰州, 730000
|
语种
|
中文 |
文献类型
|
研究性论文 |
ISSN
|
1004-0595 |
学科
|
机械、仪表工业 |
基金
|
中国科学院西部之光人才培养计划
|
文献收藏号
|
CSCD:2448166
|
参考文献 共
16
共1页
|
1.
熊菲. 天然牙和牙科材料的摩擦学研究现状与进展.
摩擦学学报,2005,25(4):379-384
|
被引
3
次
|
|
|
|
2.
Jones D W. Zirconia ceramics as dental prosthetic.
J Can Dent Assoc,1998,64(9):648-650
|
被引
2
次
|
|
|
|
3.
马轩祥. 我国瓷修复的问题与展望.
中华口腔医学杂志,1999,34(5):261-263
|
被引
14
次
|
|
|
|
4.
He Y J. Sliding wear of ZrO2-Al2O3 composite ceramics.
J European Ceramic Society,1997:1371-1380
|
被引
1
次
|
|
|
|
5.
Kerkwijk B. Tribological properties of nanoscale alumina-zirconia composites.
Wear,1999,225/229:1293-1302
|
被引
2
次
|
|
|
|
6.
He Y J. Effects of a second phase on the tribological properties of Al2O3 and ZrO2 ceramics.
Wear,1997,210:178-187
|
被引
4
次
|
|
|
|
7.
Nagarajan V S. In vitro contact wear of dental composites.
Dental Materials,2004,20:63-71
|
被引
4
次
|
|
|
|
8.
AL-Hiyasat A S. Investigation of human enamel wear against four dental ceramics and gold.
Journal of Dentistry,1998,26:487-495
|
被引
9
次
|
|
|
|
9.
郑靖. 人牙釉质在人工唾液润滑下与不同偶件对摩时的摩擦学性能研究.
摩擦学学报,2004,24(3):139-143
|
被引
10
次
|
|
|
|
10.
Li H. Wear behavior of human teeth in dry and artificial saliva conditions.
Wear,2001,249:980-985
|
被引
10
次
|
|
|
|
11.
黎红. 天然牙及几种牙科修复材料的摩擦磨损性能比较研究.
摩擦学学报,2001,21(3):172-175
|
被引
15
次
|
|
|
|
12.
周仲荣.
生物摩擦学,2005
|
被引
1
次
|
|
|
|
13.
王广奎.
纳米氧化锆增韧氧化铝口腔复合陶瓷优化配比的研究,2005
|
被引
1
次
|
|
|
|
14.
薛群基. 陶瓷摩擦学.I.陶瓷的摩擦与磨损.
摩擦学学报,1995,15(4):376-384
|
被引
27
次
|
|
|
|
15.
陈治清.
口腔材料学,2000
|
被引
1
次
|
|
|
|
16.
Cesar P F. Correlation between fracture toughness and leucite in dental porcelains.
J Dent,2005,33(9):721-729
|
被引
3
次
|
|
|
|
|