兰姆波在搭接焊缝上的反射和透射
The reflection and transmission of Lamb waves at overlap joints
查看参考文献21篇
|
文摘
|
采用数值模拟方法和实验研究了兰姆波在搭接焊缝上的反射和透射。数值模拟了频率500 kHz的兰姆波S0与A0模态,分别在2 mm厚不锈钢板上的不同宽度搭接焊缝模型上的反射和透射,并计算了相应的反射系数和透射系数。发现:当搭接焊缝宽度小于4 mm时,S0模态的反射系数和焊缝宽度具有近似的线性关系,而焊缝余高和两板之间的间隙对S0模态反射系数的影响很小。基于兰姆波S0模态反射系数与焊缝宽度的线性关系,提出了通过测量S0模态反射系数快速测量搭接焊缝宽度的方法。实验测得的2 mm厚不锈钢板上不同宽度搭接焊缝对500 kHz的入射兰姆波S0模态的反射系数,验证了上述线性关系,说明了可用兰姆波反射回波测量搭接焊缝宽度。 |
|
其他语种文摘
|
The reflection and transmission of Lamb waves at overlap joints are researched by the numerical method and the experiments. The numerical method is used to simulate the reflection and transmission occurred when the Lamb waves S0 and A0 mode (at an exciting frequency of 500 kHz) propagate through welds with different widths on a 2 mm-thick stainless steel plate. The reflection and transmission coefficients are calculated as well. When the welds widths are less than 4 mm, a quasi-linear correlation is observed between the reflection coefficient of S0 mode and the weld width. In contrast to the weld width, both the gap between two plates and the reinforcement of weld do not have obvious effect on the reflection coefficient. Based on the results, we propose that the width of weld could be rapidly measured through examining the echo amplitude of S0. Experiments using welds with different widths on a 2 mm-thick stainless steel plate further confirms the quasi-linear correlation and the feasibility of our proposed method. |
|
来源
|
声学学报
,2017,42(4):495-503 【核心库】
|
|
关键词
|
兰姆波
;
搭接焊缝
;
反射和透射
|
|
地址
|
中国科学院金属研究所, 沈阳, 110016
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
0371-0025 |
|
学科
|
金属学与金属工艺 |
|
文献收藏号
|
CSCD:6021639
|
参考文献 共
21
共2页
|
|
1.
Poddar B. Fast and accurate analytical model to solve inverse problem in SHM using Lamb wave propagation.
Proceedings of SPIE, Nondestructive Characterization and Monitoring of Advanced Materials, Aerospace, and Civil Infrastructure 2016, LAS VEGAS, 2016,2016:1-20
|
CSCD被引
1
次
|
|
|
|
|
2.
Ratassepp M. Scattering of the fundamental torsional mode at an axial crack in a pipe.
J. Acoust. Soc. Am,2010,127(2):730-740
|
CSCD被引
7
次
|
|
|
|
|
3.
Terrien N. A combined finite element and modal decomposition method to study the interaction of Lamb modes with micro-defects.
Ultrasonics,2007,46(1):74-88
|
CSCD被引
4
次
|
|
|
|
|
4.
Gravenkamp H. Simulation of elastic guided waves interacting with defects in arbitrarily long structures using the Scaled Boundary Finite Element Method.
J. Comput. Phys,2015,295:438-455
|
CSCD被引
4
次
|
|
|
|
|
5.
Santhanam S. Reflection of Lamb waves obliquely incident on the free edge of a plate.
Ultrasonics,2013,53(1):271-282
|
CSCD被引
5
次
|
|
|
|
|
6.
Feng F. The scattering matrices of Lamb waves at multiple delaminations and broken laminates.
NDT&E Int,2012,49:64-70
|
CSCD被引
2
次
|
|
|
|
|
7.
Feng F. Scattering matrices of Lamb waves at irregular surface and void defects.
Ultrasonics,2012,52(6):760-766
|
CSCD被引
5
次
|
|
|
|
|
8.
Rokhlin S I. Resonance phenomena of Lamb waves scattering by a finite crack in a solid layer.
J. Acoust. Soc. Am,1981,69(4):922-928
|
CSCD被引
4
次
|
|
|
|
|
9.
Rokhlin S I. Online ultrasonic Lamb wave monitoring of spot welds.
Mater. Eval,1985,43(7):879-883
|
CSCD被引
5
次
|
|
|
|
|
10.
Lowe M J S. The transmission of Lamb waves across adhesively bonded lap joints.
J. Acoust. Soc. Am,2000,107(3):1333-1345
|
CSCD被引
6
次
|
|
|
|
|
11.
Song W J. Ultrasonic guided wave scattering in a plate Overlap.
IEEE T. Ultrason. Ferr,2005,52(5):892-903
|
CSCD被引
4
次
|
|
|
|
|
12.
Zhang Y L. Investigation on the effects of parameters on hot cracking and tensile shear strength of overlap joint in laser welding dissimilar Al alloys.
Int. J. Adv. Manuf. Tech,2016,86(9/12):2895-2904
|
CSCD被引
3
次
|
|
|
|
|
13.
Mira-Aguiar T. Solid-state resistance seam welding of galvanized steel.
Int. J. Adv. Manuf. Tech,2016,86(5/8):1385-1391
|
CSCD被引
1
次
|
|
|
|
|
14.
Rose J L.
Ultrasonic waves in solid media,1999
|
CSCD被引
108
次
|
|
|
|
|
15.
Alleyne D N. The interaction of Lamb waves with defects.
IEEE T. Ultrason. Ferr,1992,39(3):381-397
|
CSCD被引
31
次
|
|
|
|
|
16.
Alleyne D N. Optimization of Lamb wave inspection techniques.
NDT&E Int,1992,25(1):11-22
|
CSCD被引
14
次
|
|
|
|
|
17.
Viktorov I A.
Rayleigh and Lamb waves,1967
|
CSCD被引
19
次
|
|
|
|
|
18.
Morvan B. Lamb wave reflection at the free edge of a plate.
J. Acoust. Soc. Am,2003,113(3):1417
|
CSCD被引
4
次
|
|
|
|
|
19.
Alleyne D. A two-dimensional Fourier transform method for the measurement of propagation multimode signals.
J. Acoust. Soc. Am,1991,89(3):1159-1168
|
CSCD被引
50
次
|
|
|
|
|
20.
Liu Dan. Impact of the fracture on low-order guided waves in long bone.
Chinese Journal of Acoustics,2015,34(2):166-176
|
CSCD被引
1
次
|
|
|
|
|
了解气象卫星更多信息，请访问