丙烯腈-丁二烯-苯乙烯塑料、四溴双酚A混合物的热解实验: 含溴二噁英生成研究
Experimental Investigation on the Formation of Polybrominated Dibenzo-pdioxins(PBDDs) and Dibenzofurans (PBDFs) during the Pyrolysis of Acrylonitrile- Butadiene-Styrene (ABS) and Tetrabromobisphenol A (TBBPA) Blends
查看参考文献22篇
|
文摘
|
模拟电子垃圾热回收处理过程,将丙烯腈-丁二烯-苯乙烯塑料(ABS)、四溴双酚A(TBBPA)分别与4种金属(Cu、Fe、Zn和Ni)进行混合,在自制的加热装置内开展了不同气氛、不同温度条件下热解实验研究。对产物溴代二噁英(PBDD/Fs)检测显示, 2,3,7,8-TBDF、2,3,7,8-TBDD及1,2,3,4,7,8-与1,2,3,6,7,8-HxBDD为主要产物,其中2,3,7,8-TBDF含量最高,约占总PBDD/Fs的12%~ 90%。反应生成的8种2,3,7,8-PBDD/Fs浓度范围为0.05~ 2 082 ng·g~(-1)。在同等实验条件下,温度升高有利于ABS塑料混合物中PBDD/Fs的生成。Cu、Fe、Zn和Ni四种金属都具有催化效应。空气、氮气气氛下热解实验显示,空气气氛下PBDD/ Fs的生成量大,2种条件下生成的二噁英总量比值在0.8~ 99.6之间变化。无金属催化条件下此比值变化范围较小,为0.8~ 1.5;在金属参与条件下,此比值变化范围加大,为1.2~ 99.6;其中,在Cu和Fe参与下,此比值较高。各种热解条件下形成的PBDD/Fs都具有PBDFs > PBDDs的特征。研究结果说明,虽然无金属参与条件下含TBBPA的ABS热解生成溴代二噁英浓度较低,但金属(如Cu等)存在时,此类污染物的浓度显著增加。 |
|
其他语种文摘
|
The formation of polybrominated dibenzo-p-dioxins (PBDDs) and dibenzofurans (PBDFs) during the pyrolysis of acrylonitrile-butadiene-styrene (ABS) and tetrabromobisphenol A (TBBPA) blends containing or not one of the four metals (Cu, Fe, Zn and Ni) was investigated using a self-made apparatus at different temperatures and carrier gas compositions. Results showed that 2,3,7,8-TBDF, 2,3,7,8-TBDD, 1,2,3,4,7,8-HxBDD and 1,2,3,6,7,8-HxBDD were the main products, and that the highest concentration congener was 2,3,7,8-TBDF, accounting for 12% ~ 90% of total concentration of the products. The total concentration of 2,3,7,8-PBDD/Fs ranged from 0.05 to 2 082 ng·g~(-1). Under the same conditions, high temperatures favored the formation of PBDD/Fs during the pyrolysis. The four metals were found to have a catalytic effect on the formation of PBDD/Fs. Higher concentration of PBDD/Fs was detected when air was used as carrier gas, and the ratios of ΣPBDD/Fs to the total concentration of the products under the two gas conditions (with air and N2 as carrier gas, respectively) ranged from 0.8 to 99.6. In the absence of the metals, the ratios of ΣPBDD/Fs to the total concentration of the products showed little variation (ranging from 0.8 to 1.5); while, in the presence of the metals, the ratios varied greatly from 1.2 to 99.6. Under the experimental conditions of the present study, the concentrations of PBDFs formed during the pyrolysis were much higher than those of PBDDs. The metals such as Cu could increase the formation of PBDD/Fs during the pyrolysis of ABS/TBBPA blends, although the levels of PBDD/Fs formed in the absence of the metals during the pyrolysis were relatively low. |
|
来源
|
生态毒理学报
,2016,11(2):170-178 【核心库】
|
|
DOI
|
10.7524/AJE.1673-5897.20150729001
|
|
关键词
|
溴代二噁英
;
ABS塑料
;
四溴双酚A
;
金属
;
热解
|
|
地址
|
中国科学院广州地球化学研究所, 有机地球化学国家重点实验室;;广东省环境资源利用与保护重点实验室, 广州, 510640
|
|
语种
|
中文 |
|
文献类型
|
研究性论文 |
|
ISSN
|
1673-5897 |
|
学科
|
环境科学基础理论 |
|
基金
|
国家自然科学基金
|
|
文献收藏号
|
CSCD:5766933
|
参考文献 共
22
共2页
|
|
1.
Ladou J. Printed circuit board industry.
International Journal of Hygiene and Environmental Health,2006,209(3):211-219
|
CSCD被引
11
次
|
|
|
|
|
2.
Guo J Y. Recycling of non-metallic fractions from waste printed circuit boards: A review.
Journal of Hazardous Materials,2009,168(2/3):567-590
|
CSCD被引
24
次
|
|
|
|
|
3.
Wang R. Recycling of non-metallic fractions from waste electrical and electronic equipment (WEEE): A review.
Waste Manage,2014,34(8):1455-1469
|
CSCD被引
13
次
|
|
|
|
|
4.
彭平安. 电子垃圾的污染问题.
化学进展,2009,21(2/3):550-557
|
CSCD被引
17
次
|
|
|
|
|
5.
高丹丹. 不同暴露方式四溴双酚A的代谢及毒性特征.
环境与健康杂志,2015,32(2):165-168
|
CSCD被引
2
次
|
|
|
|
|
6.
Lenoir D. The influence of water and metals on PBDD/F concentration in incineration of decabrombiphenyl ether in polymeric matrices.
Chemosphere,1994,28(11):1921-1928
|
CSCD被引
3
次
|
|
|
|
|
7.
Luijk R. The influence of the polymer matrix on the formation of polybrominated dibenzo-pdioxins (PBDDs) and polybrominated dibenzofurans (PBDFs).
Chemosphere,1991,23(8/10):1173-1183
|
CSCD被引
2
次
|
|
|
|
|
8.
Thies J. Tetrabromobisphenol A (TBBA), its derivatives and their flame retarded (FR) polymers- Content of polybrominated dibenzo-p-dioxins (PBDD) and dibenzofurans (PBDF)-PBDD/F formation under processing and smouldering (worst case) conditions.
Chemosphere,1990,20(10/12):1921-1928
|
CSCD被引
3
次
|
|
|
|
|
9.
李会茹. 大气样品中氯代和溴代二噁英/呋喃同位素稀释分析方法的建立及应用.
分析化学研究报告,2008,36(2):150-156
|
CSCD被引
2
次
|
|
|
|
|
10.
肖潇. 贵屿某电子垃圾拆解点附近大气颗粒物中氯代/溴代二英、四溴双酚A污染水平研究.
环境科学学报,2012,32(5):1142-1148
|
CSCD被引
14
次
|
|
|
|
|
11.
Alaee M. An overview of commercially used brominated flame retardants, their applications, their use patterns in different countries/regions and possible modes of release.
Environment International,2003,29(6):683-689
|
CSCD被引
143
次
|
|
|
|
|
12.
肖望东. 阻燃ABS及其耐热性研究.
工程塑料应用,2004,32(11):14-16
|
CSCD被引
3
次
|
|
|
|
|
13.
He W. WEEE recovery strategies and the WEEE treatment status in China.
Journal of Hazardous Materials,2006,136(3):502-512
|
CSCD被引
26
次
|
|
|
|
|
14.
Ebert J. Formation of PBDD/F from flame-retarded plastic materials under thermal stress.
Environment International,2003,29(6):711-716
|
CSCD被引
15
次
|
|
|
|
|
15.
Bonilla J. Analyses of brominated dibenzo-p-dioxins and dibenzofurans in ABS resins containing brominated flame retardants.
Journal of Fire Sciences,1990,8(6):395-404
|
CSCD被引
1
次
|
|
|
|
|
16.
Luijk R. The formation of polybrominated dibenzo-p-dioxins (PBDDs) and dibenzofurans (PBDFs) during pyrolysis of polymer blends containing brominated flame retardants.
Chemosphere,1992,25(3):361-374
|
CSCD被引
2
次
|
|
|
|
|
17.
Wichmann H. Thermal formation of PBDD/F from tetrabromobisphenol A-A comparison of polymer linked TBBP A with its additive incorporation in thermoplastics.
Chemosphere,2002,47(4):349-355
|
CSCD被引
8
次
|
|
|
|
|
18.
Hutzinger O. PBDD and PBDF from brominated flame retardants: Combustion equipment, analytical methodology and synthesis of standards.
Chemosphere,1989,18(1):1235-1242
|
CSCD被引
1
次
|
|
|
|
|
19.
Duan H B. Characterization and inventory of PCDD/Fs and PBDD/Fs emissions from the incineration of waste printed circuit board.
Environmental Science & Technology,2011,45(15):6322-6328
|
CSCD被引
16
次
|
|
|
|
|
20.
Lai Y C. Inhibition of polybrominated dibenzo-p-dioxin and dibenzofuran formation from the pyrolysis of printed circuit boards.
Environmental Science & Technology,2007,41(3):957-962
|
CSCD被引
4
次
|
|
|
|
|
了解气象卫星更多信息，请访问